Gallery: SpaceX's 1st Mission to Space Station - How It Works

Step 1: Launch

SpaceX

Commercial space firm SpaceX plans to launch the first non-governmental spaceship to dock with the International Space Station May 19.

SpaceX's unmanned Dragon capsule is due to deliver food, supplies and science experiments to the orbiting laboratory as a test mission for NASA's Commercial Orbital Transportation Services (COTS) program, aimed at spurring development of replacement cargo ferries for the retired space shuttles.

Here's how the robotic mission will play out:

The Dragon capsule is set to lift off aboard SpaceX's Falcon 9 rocket from Cape Canaveral Air Force Station in Florida. SpaceX has use of the facility's Space Launch Complex 40. The initial ascent is powered by Falcon 9's first stage, consisting of nine SpaceX Merlin 1C rocket engines.

Step 2: Main Engine Cut Off/Stage Separation

SpaceX

At a little before 180 seconds into the flight, the Falcon 9's first stage engines will cut off, and the first stage will drop off, falling back to Earth. At this point, the booster's second stage engines should start, further propelling the vehicle into orbit.

Step 3: Payload Separation

NASA

Around 9 minutes into the flight, the Dragon capsule should separate from Falcon 9's second stage and orbit on its own. The capsule will deploy its solar arrays to start soaking up energy from the sun. At this point, Dragon is on its own and must maneuver using its onboard thrusters. [The World's Tallest Rockets: How They Stack Up]

Step 4: Orbital Checkouts

SpaceX

After reaching orbit, Dragon will begin a series of checkouts to make sure it's functioning as designed and ready to meet up with the station.

Teams on the ground will lead the vehicle through tests of its Absolute GPS (AGPS) system, which uses global positioning system satellites to determine its location in space. It will also demonstrate its performance in free drift phase, with thrusters inhibited. Finally, Dragon will test out its abort system to prove it can terminate its activities and move away from the space station if something goes wrong.

Step 5: Fly-Under

NASA

During its third day in orbit, Dragon will fire its thrusters to perform a fly-under of the International Space Station, swooping to 1.5 miles (2.5 kilometers) below the outpost. At this point, the capsule will make radio contact with the station using a system called the COTS Ultra‐high frequency Communication Unit to communicate.

During the fly-under, Dragon will also test a secondary locator system called the relative GPS system, which uses the spacecraft's position relative to the space station to establish its coordinates.

While Dragon is flying under the station, the six-person crew inside the orbiting laboratory will be monitoring their new visitor. They will use a crew command panel onboard the station to communicate with the capsule and send it a command to turn on a strobe light.

After completing the fly-under, Dragon will loop out in front, above and then behind the space station to position itself for docking.

Step 6: Rendezvous

SpaceX/NASA

The next day, during Dragon's fourth day of flight, the spacecraft will fire its thrusters again to bring it within 1.5 miles (2.5 kilometers) of the space station. Once there, NASA's Mission Control team in Houston will run through a "go-no go" call to confirm all teams are ready for rendezvous. If everyone is "go," Dragon will inch closer, to about 820 feet (250 meters) away from the space station.

At this point, a series of final checkouts will be performed to make sure all of Dragon's location and navigation systems are accurate. If all looks good, Dragon's SpaceX control team on the ground will command the vehicle to approach the space station. When it reaches 720 feet (220 meters), the astronauts onboard the outpost will command the capsule to halt.

After another series of "go-no go" checks, Dragon will approach to 656 feet (200 meters), and then 98 feet (30 meters), and finally 32 feet (10 meters), the capture point.

Step 7: Docking

SpaceX

At this position, Mission Control will tell the space station crew they are "go" for capturing Dragon. NASA astronaut Don Pettit will use the station's robotic arm to reach out and grab Dragon, pulling it in to the bottom side of the lab's Harmony node, and then attaching it.

The next day, after more checkouts, the crew will open the hatch between Dragon and the station. Over the coming weeks, the astronauts will spend about 25 hours unpacking the 1,014 pounds (460 kilograms) of cargo that Dragon delivers. Though none of the cargo is critical (since this is a test flight), the capsule will arrive bearing food, water, clothing and supplies for the crew.

Step 8: Undocking

SpaceX

Dragon is due to spend about 18 days docked at the International Space Station. When it's time to let it go, the station astronauts will use the robotic arm to maneuver the capsule out to about 33 feet (10 meters) away, then release it. Dragon will then use its thrusters to fly a safe distance away from the laboratory.

Step 9: Re-entry

SpaceX/Roger Gilbertson

About four hours after departing the space station, Dragon will fire its engines to make what's called a de-orbit burn. This burn will set the capsule on a course for re-entry through Earth's atmosphere. The spacecraft is equipped with a heat shield to protect it from the fiery temperatures of its 7-minute re-entry flight.

Step 10: Landing

SpaceX/Mike Altenhofen

Dragon is due to splash down in the Pacific Ocean to end its mission. There, recovery crews will be waiting to collect the capsule about 250 miles (450 kilometers) off the West Coast of the United States.

Join our Space Forums to keep talking space on the latest missions, night sky and more! And if you have a news tip, correction or comment, let us know at: community@space.com.

Clara Moskowitz
Assistant Managing Editor

Clara Moskowitz is a science and space writer who joined the Space.com team in 2008 and served as Assistant Managing Editor from 2011 to 2013. Clara has a bachelor's degree in astronomy and physics from Wesleyan University, and a graduate certificate in science writing from the University of California, Santa Cruz. She covers everything from astronomy to human spaceflight and once aced a NASTAR suborbital spaceflight training program for space missions. Clara is currently Associate Editor of Scientific American. To see her latest project is, follow Clara on Twitter.